dieseltaylor Posted February 27, 2012 Share Posted February 27, 2012 Interesting article, and perhaps future costs for the military: Equipment Noise is Accelerating Hearing Loss By Paul McLeary In September 2007, a U.S. Navy officer working with the Marines' executive safety board issued a simple, stark warning. According to a presentation by Cdr. Stan Jossell, the Marines -- and to some extent the services in general -- are buying new equipment that is so loud that it's not a matter of whether but when and how badly operators will suffer permanent hearing damage. Jossell noted, moreover, that the technology to protect users from damage does not yet exist. Jossell, who declined to be interviewed for this article, singled out the F-35 Joint Strike Fighter and the Expeditionary Fighting Vehicle (EFV) as particular problems. Noise levels for these systems "will result in permanent hearing loss," he wrote. "We are not protecting our people . . . [Program Executive Office] Tacair has accepted the 'serious risk' for the F/A-18E/F and EA-18G engine noise. Yet we are actually accepting the probability of permanent injury, not the risk of the occurrence." Hearing loss is expensive. Jossell's study found that the cost for treating hearing loss among all veterans was over $900 million in 2006 -- up from about $200 million in 1996 -- and that with new technologies coming on line, the Navy and Marines are placing their personnel "in work environments where permanent hearing loss is a given." The problem, the report concludes, is that "we continue to design and procure weapon systems so loud that even the best noise attenuation possible cannot prevent hearing loss." What has made the problem worse? Essentially, noise levels are associated with performance. The EFV has a 2,600-hp. diesel engine to drive it through the water at a maximum speed of 25 kt. -- substantially more power than an M1 tank -- and there is only so much that can be done to reduce noise inside its personnel compartment. The latest generation of fighters, including the F-22 and Super Hornet as well as JSF, use engines that generate more thrust per unit of airflow than earlier engines. This inevitably means higher jet velocity and that aircraft noise will rise as the fourth power of the velocity along with thrust. While most fighters expose ground crews to full-throttle noise for moments, the Stovl F-35B puts out almost 40,000 lb. of thrust for tens of seconds as it descends to the deck. Modern aircraft can put out 150-plus dB. of noise at close quarters. The best protection -- foam earplugs and active noise reduction (ANR) headphones -- only protect hearing to 134 dB. Passive measures provide about 30 dB. of noise reduction, which is nowhere close to the U.S. Labor Dept.'s mandated 85-dB. exposure limit over an 8-hr. workday. What's more, even the 30-dB. reduction isn't being met by the vast majority of sailors. According to recent reports, Naval Air Systems Command estimates that only about 7% of sailors insert earplugs correctly. http://www.aviationweek.com/aw/jsp_includes/articlePrint.jsp?storyID=news/DTI-hear.xml&headLine=Equipment%20Noise%20is%20Accelerating%20Hearing%20Loss 0 Quote Link to comment Share on other sites More sharing options...
Michael Emrys Posted February 27, 2012 Share Posted February 27, 2012 It's been bad for a very long time. Ten years ago I met a young man who had served a hitch on the flight deck of an aircraft carrier and who had a significant hearing loss. I don't know how well the guys in artillery manage. I'm sure other branches of the service have their own noise problems. Michael 0 Quote Link to comment Share on other sites More sharing options...
Recommended Posts
Join the conversation
You can post now and register later. If you have an account, sign in now to post with your account.